THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.

Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.

NHTSA campaign 10V110000

DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.

Consequence: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.

Remedy: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

NHTSA campaign 09E005000

CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.

Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.

NHTSA campaign 05V287000

ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.

Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.

Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.

NHTSA campaign 05V061000